Slingsby T67 Firefly

RF-6, T67 Firefly
Slingsby T67M260 Firefly of the British Defence Elementary Flying Training School
Role Trainer
Manufacturer Fournier, Slingsby Aviation
First flight 12 March 1974
Retired United States Air Force 2006
Status Limited Service
Primary users Royal Jordanian Air Force
Belize Defence Force Air Wing
Bahrain Air Force
Produced 1974-1995
Number built > 250
Developed into Sportavia RS-180

The Slingsby T67 Firefly, originally produced as the Fournier RF-6, is a two-seat aerobatic training aircraft, built by Slingsby Aviation in Kirkbymoorside, Yorkshire, England.[1] It has been successfully used by the UK armed forces, where the Royal Air Force used 22 Slingsby T67M260s as their basic trainer between 1995 and 2010, with over 100,000 flight hours flown out of RAF Barkston Heath. The Slingsby has also been used by the Royal Hong Kong Auxiliary Air Force, the Royal Jordanian Air Force (still currently used), and other military training schools around the world for many years. Also, in December 2012, the National Flying Laboratory Centre at Cranfield University in the UK acquired a T67M260 to supplement its Scottish Aviation Bulldog aerobatic trainer for MSc student flight experience and training.

The Slingsby is a very competent basic trainer and is still operated by many private individuals for standard-level aerobatics training. It was the HRH Prince Harry's basic trainer during his RAF flying officers course based at RAF Barkston Heath, including his first solo flight in Slingsby T67M260 registration G-BWXG in 2009.[2] Tom Cassells a British Aerobatic Champion regularly flies his Slingsby Firefly. However, in the mid-1990s, the aircraft became controversial in the United States after three fatal accidents during US Air Force training operations, although an Air Force investigation eventually attributed the accidents primarily to pilot error.

Development

The RF-6 was designed by René Fournier, and first flew on 12 March 1974. An all-wooden construction, it featured a high aspect-ratio wing echoing his earlier motorglider designs. Fournier set up his own factory at Nitray to manufacture the design, but after only around 40 had been built, the exercise proved financially unviable, and he was forced to close down production. A four-seat version was under development by Sportavia as the RF-6C, but this demonstrated serious stability problems that eventually led to an almost complete redesign as the Sportavia RS-180.

In 1981, Fournier sold the development rights of the RF-6B to Slingsby, which renamed it the T67. The earliest examples, the T67A, were virtually identical to the Fournier-built aircraft, but the design was soon revised to replace the wooden structure with one of composite material. Slingsby produced several versions developing the airframe and adding progressively larger engines. The Slingsby T67M, aimed at the military (hence "M") training market, was the first to include a constant-speed propeller and inverted fuel and oil systems. Over 250 aircraft have been built, mainly the T67M260 and closely related T-3A variants. Although operated successfully in the United Kingdom and Canada, the program would end in the United States because of a fatal crash following an engine failure. The type was meant to not only replace the Cessna T-41 introductory trainer, but also to meet the Enhanced Flight Screening Program (EFSP) requirements. The US Air Force has no replacement for this type, as it no longer provides training to non-fliers. The aircraft were eventually declared in excess of need in the early 2000s (decade) and disposed of by scrapping in 2006.

Operational history

The largest Firefly operator was the United States Air Force, where it was given the designation T-3A Firefly. The Firefly was selected in 1992 to replace the T-41 aircraft for the command's Enhanced Flight Screening Program, which would include aerobatic maneuvers. From 1993 to 1995, 113 aircraft were purchased and delivered to Hondo Municipal Airport, Texas, and the U.S. Air Force Academy in Colorado.

The Commander of the Air Education and Training Command stood down the entire T-3A fleet in July 1997 as a result of uncommanded engine stoppages during flight and ground operations. A major factor driving the decision were the three T-3A Class A mishaps. Three Air Force Academy cadets and three instructors were killed in these T-3A mishaps. The Air Force Accident Investigation Board report summary attributed the three fatal accidents to:

i. 22 February 1995: The instructor pilot (IP) failed to apply antispin rudder as directed in flight manual. The IP’s spin academic instruction, flying training, and error analysis experience did not adequately prepare him to recognize his improper rudder application.

ii. 30 September 1996: During a simulated forced landing, the engine quit for some unknown reason. After the engine quit, the aircraft entered a stall from which the IP was unable to recover prior to ground impact.

iii. 25 June 1997: The aircraft departed controlled flight for an unknown reason during the turn to downwind. The IP’s failure to recognize this departure and take immediate positive corrective action was the primary cause of the accident. (The AIB President found no clear and convincing evidence of mechanical failure.)

In April 1995 a 3rd Flying Training Squadron lost a T-3A in a landing accident. During a planned student no-flap landing at Hondo Airfield, Hondo, Texas USA. At touchdown the student jerked the aircraft back into the air and the plane stalled. The instructor took the aircraft and applied full throttle but he couldn't prevent the crash. The aircraft touched down beside the runway and the nose gear struck the lip of a cross runway and collapsed causing loss of control and heavy damage. The only injury was a slight injury to the instructor's foot from the nose gear coming up through the cockpit floor. The mishap was classified as a Class B (non-hull loss) because it was said the aircraft could be repaired for less than $300,000 even though the Air Force chose to scrap the plane.

The planes had been purchased for $32 million, and following the third accident, $10 million was spent on fixes to make them airworthy after grounding. "The Air Force found the cost of getting the aircraft or any of the aircraft's components in airworthy condition for resale was prohibitive" and "In September 1999, the chief of staff of the Air Force approved termination of the T-3A EFSP, and AETC declared all T-3A aircraft excess to the command's needs." In 2000, the Chief of Staff of the Air Force requested a new mission be found for the T-3A; however, a study completed in 2002 did not recommend a follow-on mission. [3] "The remaining T-3A aircraft were then stored without maintenance at the Air Force Academy and the Hondo Airport. In the 2002 to 2003 timeframe, the 53 aircraft at the Air Force Academy were disassembled, crated and trucked to Hondo." On September 9, 2006, it was announced the remaining 53 (114 were originally purchased) disassembled T-3 aircraft, which had been declared in excess need for over six years, would were scrapped.[4] Edwards Air Force Base still operates a single T67M Slingsby for test pilot training which originates from the fuel system flight tests in 1998. Although the Air Force terminated the EFSP, it now uses the non-aerobatic Diamond DA20 for Initial Flight Screening through the third-party Doss Aviation.

Variants

Slingsby Firefly T67C cockpit
Slingsby T67M Firefly
RF-6B
Main Fournier production series with Rolls-Royce-built Continental O-200 100 hp (75 kW) engine (43 built)
RF-6B/120
RF-6B with Lycoming O-235 120 hp (89 kW) engine, one built
RF-6C
Four-seat version of RF-6B built by Sportavia with Lycoming O-320 engine, four built, developed into Sportavia RS-180
T67A
Slingsby-built RF-6B/120 certified on 1 October 1981, O-235 118hp engine, wooden construction, 2 blade fixed prop, fuel in firewall tank, single piece canopy, ten built
T67M Firefly
First flown on 5 December 1982 and certified on 2 August 1983, the T67M was developed from the T67A as a glass-reinforced plastic aircraft for a role as a military trainer. The T67M has a 160 hp (120 kW) fuel-injected Lycoming AEIO320-D1B and a two-blade Hoffman HO-V72L-V/180CB constant-speed propellor, single piece canopy, fuel in firewall tank. The fuel-injected engine with inverted fuel and oil systems allowed the aircraft to perform sustained negative-G (inverted) aerobatics, although inverted spins were never formally approved. A total of 32 T67Ms (including the later T67M MkII) were produced.
T67B
First flown on 16 April 1981 and certified on 18 September 1984, the T67B was effectively the T67A made, like the T67M, in glassfibre reinforced plastic, but without the up-rated engine and propeller. O-235 118hp engine, 2 blade fixed prop, fuel in firewall tank, single piece canopy. A total of 14 T67Bs were produced.
T67M MkII Firefly
Certified on 20 December 1985, AEIO-320 fuel injected 160hp engine, 2 blade constant speed prop, inverted fuel and oil systems. The T67M MkII replaced the single-piece canopy of the T67M with a two-piece design, and the single fuselage fuel tank with two, larger tanks in the wings.
T67M200 Firefly
Certified on 19 June 1987, the T67M200 was had a more powerful 200 hp (149 kW) Lycoming AEIO360-A1E with a three-bladed Hoffman propellor, inverted fuel and oil systems. A total of 26 T67M-200s were produced.
T67C Firefly
T67C Firefly
Certified on 15 December 1987, the T67C was the last of the "civilian" variants, based on the T67B with an uprated 160 hp (120 kW) Lycoming O-320 engine, but without fuel injection and inverted-flight systems found on the T67M variants. Two blade constant speed prop. Two further sub-versions of the T67C copied the two-piece canopy (T67C-2) and wing tanks (T67C-3, sometimes known as the T67D) from the T67M MkII. A total of 28 T67Cs were produced across the three versions.
T67M260 Firefly
Certified on 11 November 1993, the T67M260 added even more power from the six-cylinder, 260 hp (190 kW) Lycoming AEIO540-D4A5 engine, three blade constant speed prop. Unusually for side-by-side light aircraft, the T67M260 was built to be flown solo from the right-hand seat to allow student pilots to immediately get used to the left-hand throttle found in most military aircraft - earlier models of the T67M had a second throttle on the left-hand sidewall of the cabin. A total of 51 T67M-260s were produced. They were used to successfully train hundreds of RAF, RN, British Army, and foreign and Commonwealth pilots through Joint Elementary Flying Training School until late 2010.
T67M260-T3A Firefly
Certified on 15 December 1993, the last military version of the T67 family was the T67M260-T3A, of which the entire production run of 114 was purchased by the United States Air Force, where it was known as the T-3A. The T-3A was basically the T67M260 with the addition of air conditioning. Although the US media claimed the aircraft was to blame after four aircraft were destroyed in accidents, no engine stoppages or vapour-lock problems with the fuel system were found during very thorough tests at Edwards AFB. All three instructors killed in the accidents came from the C-141, a large-transport aircraft. Their only prior aerobatic experience was in Air Force pilot training in the T-37 and T-38 jet trainers. This, combined with thinner air at the higher density altitude of the Academy airfield and training areas, meant spin recovery was delayed and/or improper spin prevent/recovery techniques were used. Parachutes were not worn on the first fatal accident but were worn on the second and third fatal accidents. Both of these accidents were caused by low altitude spins. Following the three fatal accidents and an engine failure in the Academy landing pattern the fleet was grounded in 1997 and stored without maintenance until being destroyed in 2006.
CT-111 Firefly
Designation by the Canadian Forces internally only as aircraft are registered as civilian aircraft

Operators

Military operators

 Bahrain
 Belize
 Jordan
 Netherlands

The Firefly is used by the Royal Netherlands Air Force during pilot selection which is contracted out to TTC at Seppe Airport.

Former military operators

 Canada

The Firefly was used as a basic military training aircraft in Canada. The Canadian Fireflies entered service in 1992 replacing the CT 134 Musketeer. They were, in turn, replaced in 2006 by the German-made Grob G-120 when the contract ended. The aircraft were owned and operated by Bombardier Aerospace under contract to the Canadian Forces. Unlike the United States, there were no serious operational or maintenance issues with the Fireflies in Canadian military service.

 Hong Kong
 United Kingdom

The Firefly was used as a basic military trainer in the United Kingdom until spring 2010, when they were replaced by Grob Tutor aircraft. The aircraft are owned and operated under contract by a civilian company on behalf of the military. In the UK, it was under a scheme known as "Contractor Owned Contractor Operated" (CoCo).

 United States

Civil operators

Hong Kong /  Hong Kong
Hong Kong /  Hong Kong
New Zealand New Zealand
Turkey Turkey
United Kingdom United Kingdom

Specifications (T-3A)

Data from Brassey's World Aircraft & Systems Directory[10]

General characteristics

Performance

Accidents (T-3A)

Fatal Crash February 1995: US Air Force Academy T-3A failed to recover from a practice spin. Both instructor and student were fatally injured.

Destroyed Aircraft April 1995: Hondo Texas T-3A crashed on landing. The instructor pilot suffered a minor injury, the student pilot was uninjured. The Air Force did not consider this accident to be a Class A mishap (hull loss) because they determined the aircraft could be repaired for less than $300,000 even though they chose to scrap the airplane.

Fatal Crash September 1996: US Air Force Academy T-3A engine failure / stall / spin / crash. Both instructor and student were fatally injured.

Fatal Crash June 1997: US Air Force Academy T-3A entered an unintentional spin / crash from the Academy Airfield downwind. Both instructor and student were fatally injured.

Fatal Crash April 2016: Civilian T67 an eye witness said the aircraft stalled and entered a spin then crashed while doing aerobatics. Both pilots died, they were trainee RAF Pilots flying a recreational sortie.

See also

Aircraft of comparable role, configuration and era

A white Firefly (actually one of at least three) decorated with multicoloured spots is the aircraft owned by 'Auntie Mabel' in the BBC children's series Come Outside.

References

  1. ↑ "Slingsby T67 Firefly". Marshall Slingsby. Retrieved June 18, 2012.
  2. ↑ "Prince Harry First Solo".
  3. ↑
  4. ↑
  5. 1 2 3 Hoyle Flight International 13–19 December 2011, p. 34.
  6. ↑ "The Fleet". Auckland Aero Club. Archived from the original on October 19, 2008. Retrieved 2 November 2008.
  7. ↑ "Slingsby Firefly". North Shore Aero Club. Retrieved 29 April 2010.
  8. ↑ "Flight School and Aircraft". FTEJerez.
  9. ↑ "Swift Aircraft". Swift Aircraft.
  10. ↑ Taylor, M J H (editor) (1999). Brassey's World Aircraft & Systems Directory 1999/2000 Edition. Brassey's. ISBN 1-85753-245-7.
  11. ↑ "FAS.org T-3A Firefly". Retrieved 2007-04-10.
  • Hoyle, Craig. "World Air Forces Directory". Flight International, Vol. 180, No. 5231, 13–19 December 2011, pp. 26–52. ISSN 0015-3710.
Wikimedia Commons has media related to Slingsby T.67 Firefly.
This article is issued from Wikipedia - version of the 9/7/2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.